The semi-automatic glass-on-chip stage is affected by ambient temperature, dust, vibration and aging of internal components. Some potential problems may occur during the operation of the equipment. In order to make the equipment for long-term and stable use, it is necessary to carry out daily and regular equipment. Maintenance and maintenance.
7.1 Internal maintenance of the electrical box 1. The electrical box is kept closed under normal conditions;
2. Keep the inside of the electrical box clean;
3. No water can enter the electrical box;
4. Check the inside of the electrical box once a month, unplug the power supply, see if the wire ends are loose, and whether the components are loose or not.
7.2 Fold drive maintenance
The worm and worm mechanism is the main component to realize the film taking function of the machine, and the worm and worm mechanism is regularly maintained to improve the utilization rate of the equipment. The contents of the maintenance equipment are as follows:
1) Carry out daily inspection and maintenance: Is there any abnormal sound when the organization works? Is there any foreign matter on the surface of the worm? Whether the vibration is large during exercise;
2) Worm lubrication: Clean the surface of the worm every month and apply butter.
7.3 Maintenance of gas source treatment components
The following are the maintenance points for the gas source treatment components:
1) draining the filtered water from the filter regulator assembly;
2) Add 32# mechanical oil to the oil cup of the air source treatment unit once a month.
Note: All parts must be repaired and replaced with original parts. Before performing maintenance and inspection, please make sure that the power is off and the gear unit has cooled down, otherwise it will cause harm to the human body!
7.4 <br> <br> vacuum pump maintenance vacuum pump for maintenance according to actual situation need to be maintained as follows:
1) Carry out daily inspection and maintenance: Does the vacuum pump work abnormally? Whether there is obvious vibration during work;
2) Check the oil level of the vacuum pump regularly, and refuel when the oil level is low. Please refill the vacuum pump oil for this pump when refueling;
3) Check the vacuum gas pipeline according to the use of the site, if it is found that the vacuum suction time is too long, etc.;
4) The vacuum pump is replaced once a year.
7.5 Other maintenance of the filming station
1) Adding butter to the bearing at both ends of the arm, the driving drive wheel, the bearing at both ends of the driven wheel, the movable lever of the cymbal, the universal wheel, the directional wheel and related moving parts for one and a half months;
2) The table top felt is cleaned once a day after use;
3) The remote control battery is replaced once every 6 months;
4) The thermal relay reset button is reset once every two months;
5) The electrical control box terminal is re-examined for 6 months (remember to turn off the main power supply);
6) If the air flotation effect is reduced during the use of the equipment, it can be adjusted according to the total height of the table;
7) If there is glass slag or other impurities found in the inner tank of the suction cup, it should be cleaned immediately;
8) The four-link locking sleeve of the flip arm is checked once every 3 months to prevent loosening;
9) Regularly check whether the stomata of the table are blocked;
10) Fan base screw, travel motor and reducer docking Luojingsi for 6 months.
A convenient, ready-to-use, intermediate-level disinfecting wipe available in two sizes to fit all your needs. Towels stay fully saturated and will not dry out during use.For use on nonporous surfaces. Sturdy and durable, nonwoven towelette will not bunch up or tear during use.A wipes is a moist tissue used to wipe the skin.The wet towel on the market can be divided roughly into two kinds: one kind is oneself already was disinfected, but cannot disinfect other article, contain the composition that protects skin inside, can do skin moist maintain only.Another kind is not only itself is disinfected, but also can have the disinfecting effect to other articles disinfection wipes, can be used for skin abrasions, scratches and other disinfection or sterilization.The function that must see wet towel paper clearly when buying wet towel and position.
disinfective wipes, disinfectant wipes, alcohol wipes, wet wipes, sanitizer wipes
SUZHOU QIANTENG GARMENTS CO., LTD. , https://www.garmentfactorychina.com